Camera Interfaces

TL 6032 USB 3.0 Interface, Horizontal USB3 Micro B Connector

USB 3.0 interface for Block Cameras

The TL6032 USB 3.0 interface board from AIVION connect to the digital video interface of the block cameras and supports progressive HDTV formats. As no analog to digital conversion is done on these modules, excellent output image quality is guaranteed.

Datasheet TL6035

Features

  • Provides a small size, easy to use HDTV USB 3.0 compliant video streaming capture solution
  • Up to 1080p30 uncompressed HDTV video data, 4:2:2 YUV format
  • The module receives digital video signals at the input and sends UVC (USB Video Class) compliant data packets containing digital video payload to a connected host computer
  • Operates always as Super Speed USB3.0 device (Host or OTG operation modes are not supported)
  • Host computer must run a UVC capable operating system (e.g. Microsoft Windows 7)
  • Parallel up- and downstream of camera control and status data is possible (USB CDC)
  • The input supports multiplexed LVDS based video data
  • LVDS data format provided by FCB-EV, -EH, -SE and FCB-H11 camera blocks
  • Full USB bus powered camera solution possible depending on camera
  • Power supply voltage for camera is generated onboard

Supported Video Standards

The following HDTV video standards are supported by the TL6032. Note that video standard availability is always dependent on the capability of the camera block used. As interlace video modes are not supported, make sure to set camera to any supported progressive video mode to enable correct video image data transmision to any host PC.

  • 1920x1080p @ 25Hz, 29.97Hz, 30 Hz
  • 1280x720p @ 50Hz, 59.94Hz, 60Hz, 25Hz, 29.97Hz, 30Hz

Blockdiagram TL6032

TL6035 Blockdiagram
Blockdiagramm TL6035

TL6032 MP1010M-VC Camera Evaluation Kit

Partnumber: TL6032-EVK-MP1010M-VC

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • Tamron MP1010M-VC Camera
  • USB 3.0 Board (TL6032)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
  • Power supply and control interface board (EK-PA1100-USB)
  • 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
  • USB to serial adapter (TL-EVK-USB-SA)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • AIVION Visca Camera Control Software

TL6032 MP1110M-VC Camera Evaluation Kit

Partnumber: TL6032-EVK-MP1110M-VC

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • Tamron MP1110M-VC Camera
  • USB 3.0 Board (TL6032)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
  • Power supply and control interface board (EK-PA1100-USB)
  • 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
  • USB to serial adapter (TL-EVK-USB-SA)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • AIVION Visca Camera Control Software

The TL6032 USB Interface supports following HD Cameras:

  • Sony FCB-EV7520A and the legacy Sony HD Block Cameras
  • Tamron Block Cameras
  • AIVION AZM Block Cameras
  • Every other module camera with LVDS Output

Sony FCB-EV7520A

Name FCB-EV7520A
Datasheet FCB-EV7520A
Video Output Digital Digital : Y / Pb / Pr 4:2:2 (LVDS) (Y: 8 bit, C: 8 bit, Vsync, Hsync, Field, Clock) (SMPTE274M/SMPTE296M)
Video Output Analog (CVBS) PAL / NTSC
Camera Control Interface VISCA protocol (CMOS 5V Level) ; Baud Rate : 9.6 kbps, 19.2 kbps, 38.4 kbps, 115.2 kbps, Stop bit : 1 bit
Effectiv numbers of Pixels Approx. 2.130.000 pixels
Image sensor 1/2,8- type Exmor R CMOS
Signal System(HD) 1080p/60, 1080p/59.94, 1080p/50, 1080p/30, 1080p/29.97, 1080p/25, 1080i/60, 1080i/59.94, 1080i/50, 720p/60, 720p/59.94, 720p/50, 720p/30, 720p/29.97, 720p/25
Lens 30x optical zoom ; f= 4.3 mm to 129 mm, F1.6 to F4.7
Horizontal viewing angle (wide to tele) 63.7° to 2.3°
Digital Zoom 12x
Sony FCBEV-7520A
Sony FCBEV-7520A

Tamron Module Cameras

Name MP1010M-VC MP1110M-VC
Datasheet MP1010M-VC MP1110M-VC
Video Output Digital LVDS (Y/Pb/Pr 4:2:2) LVDS (Y/Pb/Pr 4:2:2)
Video Output Analog CVBS
Camera Control Interface Visca Protocol Visca Protocol
Effectiv numbers of Pixels Approx. 4,080,000 pixels Approx. 4,080,000 pixels
Image sensor 1/3-type CMOS (Progressive Scan) 1/3-type CMOS (Progressive Scan)
Signal system (HD) 1080p/60, 1080p/50, 1080p/30, 1080p/25, 1080i/60,1080i/50, 720p/60, 720p/50, 720/30p, 720/25p 1080p/60, 1080p/59.94, 1080p/50, 1080p/30, 1080p/29.97, 1080p/25, 1080i/60, 1080i/59.94, 1080i/50, 720p/60, 720p/59.94, 720p/50, 720p/30, 720p/29.97, 720p/25
Lens 10x optical zoom f=3.3 mm (wide) to 33.0 mm (tele) F1.8 to F3.4 10x optical zoom f=3.3 mm (wide) to 33.0 mm (tele) F1.8 to F3.4
Horizontal viewing angle (wide to tele) 58.2 degrees to 6.9 degrees 58.2 degrees to 6.9 degrees
Digital Zoom 16x
Tamron MP1110-VC
Tamron MP1110-VC

AIVION Cameras

Name AZM-FS10L AZM-FS20L AZM-FS30L2 AZM-WQHS36L-LL
Datasheet AZM-FS10L AZM-FS20L AZM-FS30L2 AZM-WQHS36L-LL
Video Output Digital LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits, 20bits (single LVDS mode) LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits, 16bits LVDS
Video Output Analog SD CVBS (NTSC/PAL), 1.0Vp-p 75, Composite SD CVBS (NTSC/PAL), 1.0Vp-p 75, Composite HD-Analog / CVBS(※ Test Only)
Camera Control Interface Visca Protocol Visca Protocol Visca Protocol Visca Protocol
Effectiv numbers of Pixels Approx. 2,100,000 pixels Approx. 2,100,000 pixels Approx. 2,100,000 pixels Approx. 5,450,000 pixels
Image sensor 1/2.8 inch Sony Starvis CMOS Sensor (Progressive Scan) 1/3-type CMOS (Progressive Scan) 1/2.8 inch Sony Starvis CMOS Sensor (Progressive Scan) 1/1.8" Sony IMX178LQJ-C CMOS Sensor (Progressive Scan)
Signal system (HD) 1920x1080p@25,30,50,60
1920x1080p@29.97,59.94 (optional) 1920x1080i@50,60
1920x1080i@59.94 (optional) 1280x720p@25,30,50,60 1280x720p@29.97,59.94 (optional)
1920x1080p@25,30,50,60 1920x1080i@50,60 1280x720p@25,30,50,60 1920x1080p@25,30,50,60,29.97,59.94 1920x1080i@50,60,59.94 1280x720p@25,30,50,60,29.97,59.94 1440p 30(25)fps,
1080p 30(25)fps, 720p 30(25)fps
Lens Optical 10x, f = 4.7 mm to 47.0 mm (F 1.6 to F 3.0) Optical 20x, f = 4.7 mm to 94 mm (F 1.6 to F 3.5) Optical 30x, f = 4.7 mm to 141 mm (F 1.5 to F 4.0) Optical x36, f = 6.0 mm to 216 mm (F1.5 to F4.8)
Horizontal viewing angle (wide to tele) 57.7 degrees(WIDE), 6.4 degrees(TELE) 57.4 degrees(WIDE), 3.2 degrees(TELE) 60.5 degrees(WIDE) to 2.3 degrees(TELE) 49.27 degrees(WIDE) to 1.85 degrees(TELE)
Digital Zoom 12x 12x 12x 32x

TL6032 Sony FCB EV-7500A Camera Evaluation Kit

Partnumber: TL6032-EVK-FCB-EV7500A

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • Sony FCB EV-7520A Camera
  • USB 3.0 Board (TL6032)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
  • Power supply and control interface board (EK-PA1100-USB)
  • 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
  • USB to serial adapter (TL-EVK-USB-SA)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • AIVION Visca Camera Control Software

TL6032 Evaluation Kit

Partnumber: TL6032-EVK

The evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • USB 3.0 Board (TL6032)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
  • Power supply and control interface board (EK-PA1100-USB)
  • 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
  • USB to serial adapter (TL-EVK-USB-SA)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • AIVION Visca Camera Control Software

TL6032 Production Kit

Partnumber: TL6032

Production kit with all items needed for production. Powerful, cheap , competitive

Parts:

  • TL6032 Board
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)

Camera connecting cable

Partnumber: TLCK-K30-200

KEL USL cable for the TL6032 interface board

Parts:

  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm

TL6032 Camera Evaluation Kit

Partnumber: TL6032-EVK-AZM-FSXXL

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • AZM-FS10L, AZM-FS20L, AZM-FS30L or AZM-WQHS36L-LL Block Camera
  • USB 3.0 Board (TL6032)
  • Power supply and control interface board (EK-PA1100-USB)
  • 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
  • USB to serial adapter (TL-EVK-USB-SA)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • AIVION Visca Camera Control Software