Camera Interfaces

TL 6035 | USB 3.0 Interface, Vertical USB3.0 for Sony FCB

USB 3.0 interface for Sony’s FCB-EV, FCB-EH, FCB-H and FCB-SE

The TL6035 USB 3.0 interface board from AIVION is a tiny and easy to use HDTV USB3.0 video capture interface for the Sony block camera FCB-EH/SE/EV series. The module receives digital video signals and sends UVC (USB Videl Class) compliant data packets to a connected host computer. Our compact TL6035 module enables the design of small camera systems that need only a single connection between camera and PC. Video stream, control data and power will be connected by a USB 3.0 cable. For camera blocks that need more than 900 mA during startup a Y-cable is required.

Features

  • Provides a small size, easy to use HDTV USB 3.0 compliant video streaming capture solution
  • Up to 1080p30 uncompressed HDTV video data, 4:2:2 YUV format
  • The module receives digital video signals at the input and sends UVC (USB Video Class) compliant data packets containing digital video payload to a connected host computer
  • Operates always as Super Speed USB3.0 device (Host or OTG operation modes are not supported)
  • Host computer must run a UVC capable operating system (e.g. Microsoft Windows 7)
  • Parallel up- and downstream of camera control and status data is possible (USB CDC)
  • The input supports multiplexed LVDS based video data
  • LVDS data format provided by FCB-EV, -EH, -SE and FCB-H11 camera blocks
  • Full USB bus powered camera solution possible depending on camera
  • Power supply voltage for camera is generated onboard

Supported Video Standards

The following HDTV video standards are supported by the TL6035. Note that video standard availability is always dependent on the capability of the camera block used. As interlace video modes are not supported, make sure to set camera to any supported progressive video mode to enable correct video image data transmision to any host PC.

  • 1920x1080p @ 25Hz, 29.97Hz, 30 Hz
  • 1280x720p @ 50Hz, 59.94Hz, 60Hz, 25Hz, 29.97Hz, 30Hz

Blockdiagram TL6035

TL6035 Blockdiagram
Blockdiagramm TL6035

The TL6035 USB 3.0 Interface supports Sony FCB Cameras (Series EV,H,EH,SE)

Sony FCBEV-7100
Sony FCB
Model Video output Camera control interface Image Device Effective Pixels Horizontal Viewing Angle Lens Value
FCB-EH3150 HD: Analog: Component (Y/Pb/Pr) HD: Digital: Y/Cb/Cr 4:2:2 via LVDS SD: VBS VISCA protocol (TTL signal level) 1/4-type Exmor CMOS Sensor Approximately 1.43m 53.4° (wide end) to 4.6° (tele end) 12x Optical Zoom, f=3.7 mm (wide) to 44.4 mm (tele), F1.6 to F2.5
FCB-EH3300 HD: Analog: Component (Y/Pb/Pr), Digital: (Y/CB/Cr) 4:2:2 via LDS SD: VBS VISCA protocol (TTL signal level) 1/4-type Exmor CMOS Sensor Approximately 1.45m 55.9° (wide end) to 2.9° (tele end) 20x Optical zoom, f=3.5 mm (wide) to 70.0 mm (tele), F1.35 to F3.4
FCB-EH3310 HD: Analog: Component (Y/Pb/Pr), Digital: Y/CB/Cr 4:2:2 via LVDS SD: VBS VISCA protocol (TTL signal level) 1/4-type Exmor CMOS Sensor Approximately 1.43m 55.9° (wide end) to 2.9° (tele end) 20x optical zoom, f=3.5 mm (wide) to 70.0 mm (tele), F1.35 to F3.4
FCB-EH3400 HD: Analog: Component (Y/Pb/Pr), Digital: (Y/CB/Cr) 4:2:2 via LDS SD: VBS VISCA protocol (TTL signal level) 1/4-type Exmor CMOS Sensor Approximately 1.45m 55.9° (wide end) to 2.1° (tele end) 28x Optical zoom, f=3.5 mm (wide) to 98.0 mm (tele), F1.35 to F3.7
FCB-EH3410 HD: Analog: Component (Y/Pb/Pr), Digital: (Y/CB/Cr) 4:2:2 via LDS SD: VBS VISCA Protocol 1/4-type Exmor CMOS Sensor Approximately 1.45m 55.9° (wide end) to 2.1° (tele end) 8x Optical zoom, f=3.5 mm (wide) to 98.0 mm (tele), F1.35 to F3.7
FCB-EH6300 Digital: Y/Cb/Cr 4:2:2 via LVDS VISCA (TTL Signal Level) Baud Rate: 96 Kb/s, 19.2 Kb/s, 38.4 Kb/s Stop bit: 1/2 bit selectable 1/2.8 type Exmor CMOS sensor Approx. 2 million 54.1° (wide end) to 2.9° (tele end) 20x Optical Zoom, f=4.7 mm (wide) ~ 94.0 mm (tele), F1.6 to F3.5
FCB-EH6500 Digital: Y/Cb/Cr 4:2:2 via LVDS VISCA (TTL Signal Level) Baud Rate: 96 Kb/s, 19.2 Kb/s, 38.4 Kb/s Stop bit: 1/2 bit selectable 1/2.8 type Exmor CMOS sensor Approx. 3.27 million 54.1° (wide end) to 2.9° (tele end) 30x Optical Zoom, f=4.3 mm (wide) ~ 129.0 mm (tele), F1.6 to F4.7
FCB-EV5300 Digital: Y/Cb/Cr 4:2:2 via LVDS (Signal format conforms to SMPTE 296.) VISCA (CMOS 5 V level) Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps, 115.2 Kbps, Stop bit: 1 bit 1/3.0 type Exmor CMOS Approx. 1.37 Mega Pixels 54.1°(wide end) to 2.9°(tele end) 20x optical zoom; f = 4.7 mm (wide) to 94.0 mm (tele); F1.6 to F3.5
FCB-EV5500 Analog: Component (Y/Pb/Pr); Digital: Y/Cb/Cr 4:2:2 via LVDS; (Signal format conforms to SMPTE 296.) VISCA (CMOS 5 V level); Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps, 115.2 Kbps, Stop bit: 1 bit 1/3.0 type Exmor CMOS Approx. 1.37 Megapixels 58.3°(wide end) to 2.1°(tele end) 30x optical zoom; f=4.3mm (wide) to 129.0mm (tele); F1.6 to F4.7
FCB-EV7100 Analog: Component (Y/Pb/Pr); Digital: Y/Cb/Cr 4:2:2 via LVDS;(Signal format conforms to SMPTE 274/SMPTE 296.) VISCA protocol (CMOS 5V level); Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps, 115.2 Kbps, Stop bit: 1 bit 1/2.8 type Exmor CMOS Approx. 2.38 Mega Pixels 67.0°(wide end) to 7.6°(tele end) 10x optical zoom; f=3.8mm (wide) to 38mm (tele); F1.8 to F3.4
FCB-EV7300 HD: Analog: Component (Y/Pb/Pr); Digital: Y/Cb/Cr 4:2:2 via LVDS (Signal format conforms to SMPTE 274/SMPTE 296.)SD: VBS VISCA protocol 1/2.8 type Exmor CMOS Approx. 2.38 Mega Pixels 59.5°(wide end) to 3.3°(tele end) NA
FCB-EV7310 HD: Digital: Y/Cb/Cr 4:2:2 via LVDS (Signal format conforms to SMPTE 274/SMPTE 296.)SD: VBS VISCA (CMOS 5 V level); Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps, 115.2 Kbps, Stop bit: 1 bit 1/2.8 type Exmor CMOS Approx. 2.38 Mega Pixels 59.5°(wide end) to 3.3°(tele end); SD 44.6°(wide end) to2.5°(tele end) 20x optical zoom; = 4.7 mm (wide) to 94.0 mm (tele); F1.6 to F3.5
FCB-EV7500 HD: Digital: Y/Cb/Cr 4:2:2 via LVDS (Signal format conforms to SMPTE 274/SMPTE 296.)SD: VBS VISCA (CMOS 5 V level); Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps, 115.2 Kbps, Stop bit: 1 bit 1/2.8 type Exmor CMOS Approx. 2.38 Mega Pixels 59.5°(wide end) to 3.3°(tele end); SD 44.6°(wide end) to2.5°(tele end) 30x optical zoom; f=4.3mm (wide) to 129.0mm (tele); F1.6 to F4.7
FCSE600 Digital Y/Pb/Pr 4:2:2, LVDS VISCA (CMOS 5 V level) Baud rate: 9.6 Kbps, 19.2 Kbps, 38.4 Kbps Stop bit: 1 bit 1/2.8-type Exmor CMOS Approx. 3.27 Megapixels H, 1080p mode: 90° (wide) to 32° (tele) H, 720p mode: 60° (wide) to 21° (tele) 3x

TL6035 Sony FCB EV-7100 Camera Evaluation Kit

Partnumber: TL6035-EVK-FCB-EV7100

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • Sony FCB EV-7100 Camera
  • USB 3.0 Board (TL6035)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)

TL6035 Sony FCB EV-7500 Camera Evaluation Kit

Partnumber: TL6035-EVK-FCB-EV7500

The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • Sony FCB EV-7500 Camera
  • USB 3.0 Board (TL6035)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)

TL6035 Evaluation Kit

Partnumber: TL6035-EVK

The evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.

Parts:

  • USB 3.0 Board (TL6035)
  • Bracket and screws (TL-EVK-BRA)
  • USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
    (TL-EVK-USB3.0-A-microB)
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)

TL6035 Production Kit

Partnumber: TL6035

Production kit with all items needed for production. Powerful, cheap , competitive

Parts:

  • TL6032 Board
  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)

Camera connecting cable

Partnumber: TLCK-K30-200

KEL USL cable for the TL6032 interface board

Parts:

  • 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm