Camera Interfaces
TL 6035 USB 3.0 Interface, Vertical USB3.0
USB 3.0 interface Block Cameras
The TL6035 USB 3.0 interface board from AIVION is a tiny and easy to use HDTV USB3.0 video capture interface for the block cameras. The module receives digital video signals and sends UVC (USB Video Class) compliant data packets to a connected host computer. Our compact TL6035 module enables the design of small camera systems that need only a single connection between camera and PC. Video stream, control data and power will be connected by a USB 3.0 cable. For camera blocks that need more than 900 mA during startup a Y-cable is required.
Features
- Provides a small size, easy to use HDTV USB 3.0 compliant video streaming capture solution
- Up to 1080p30 uncompressed HDTV video data, 4:2:2 YUV format
- The module receives digital video signals at the input and sends UVC (USB Video Class) compliant data packets containing digital video payload to a connected host computer
- Operates always as Super Speed USB3.0 device (Host or OTG operation modes are not supported)
- Host computer must run a UVC capable operating system (e.g. Microsoft Windows 7)
- Parallel up- and downstream of camera control and status data is possible (USB CDC)
- The input supports multiplexed LVDS based video data
- Full USB bus powered camera solution possible depending on camera
- Power supply voltage for camera is generated onboard
Supported Video Standards
The following HDTV video standards are supported by the TL6035. Note that video standard availability is always dependent on the capability of the camera block used. As interlace video modes are not supported, make sure to set camera to any supported progressive video mode to enable correct video image data transmision to any host PC.
- 1920x1080p @ 25Hz, 29.97Hz, 30 Hz
- 1280x720p @ 50Hz, 59.94Hz, 60Hz, 25Hz, 29.97Hz, 30Hz
Blockdiagram TL6035
TL6035 MP1010M-VC Camera Evaluation Kit
Partnumber: TL6035-EVK-MP1010M-VC
The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- Tamron MP1010M-VC Camera
- USB 3.0 Board (TL6035)
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
TL6035 MP3010M-EV Camera Evaluation Kit
Partnumber: TL6035-EVK-MP3010M-EV
The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- Tamron MP3010M-EV Camera
- USB 3.0 Board (TL6035)
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
The TL6035 USB Interface supports following HD Cameras:
- Sony FCB-EV7520A and the legacy Sony HD Block Cameras
- Tamron Block Cameras
- AIVION AZM Block Cameras
- Every other module camera with LVDS Output
Sony FCB-EV7520
| Name | FCB-EV7520 |
| Datasheet | FCB-EV7520A |
| Video Output Digital | Digital : Y / Pb / Pr 4:2:2 (LVDS) (Y: 8 bit, C: 8 bit, Vsync, Hsync, Field, Clock) (SMPTE274M/SMPTE296M) |
| Video Output Analog | (CVBS) PAL / NTSC |
| Camera Control Interface | VISCA protocol (CMOS 5V Level) ; Baud Rate : 9.6 kbps, 19.2 kbps, 38.4 kbps, 115.2 kbps, Stop bit : 1 bit |
| Effectiv numbers of Pixels | Approx. 2.130.000 pixels |
| Image sensor | 1/2,8- type Exmor R CMOS |
| Signal System(HD) | 1080p/60, 1080p/59.94, 1080p/50, 1080p/30, 1080p/29.97, 1080p/25, 1080i/60, 1080i/59.94, 1080i/50, 720p/60, 720p/59.94, 720p/50, 720p/30, 720p/29.97, 720p/25 |
| Lens | 30x optical zoom ; f= 4.3 mm to 129 mm, F1.6 to F4.7 |
| Horizontal viewing angle (wide to tele) | 63.7° to 2.3° |
| Digital Zoom | 12x |
Tamron Module Cameras
| Name | MP1010M-VC | MP1110M-VC |
| Datasheet | MP1010M-VC | MP1110M-VC |
| Video Output Digital | LVDS (Y/Pb/Pr 4:2:2) | LVDS (Y/Pb/Pr 4:2:2) |
| Video Output Analog | CVBS | |
| Camera Control Interface | Visca Protocol | Visca Protocol |
| Effectiv numbers of Pixels | Approx. 4,080,000 pixels | Approx. 4,080,000 pixels |
| Image sensor | 1/3-type CMOS (Progressive Scan) | 1/3-type CMOS (Progressive Scan) |
| Signal system (HD) | 1080p/60, 1080p/50, 1080p/30, 1080p/25, 1080i/60,1080i/50, 720p/60, 720p/50, 720/30p, 720/25p | 1080p/60, 1080p/59.94, 1080p/50, 1080p/30, 1080p/29.97, 1080p/25, 1080i/60, 1080i/59.94, 1080i/50, 720p/60, 720p/59.94, 720p/50, 720p/30, 720p/29.97, 720p/25 |
| Lens | 10x optical zoom f=3.3 mm (wide) to 33.0 mm (tele) F1.8 to F3.4 | 10x optical zoom f=3.3 mm (wide) to 33.0 mm (tele) F1.8 to F3.4 |
| Horizontal viewing angle (wide to tele) | 58.2 degrees to 6.9 degrees | 58.2 degrees to 6.9 degrees |
| Digital Zoom | 16x |
AIVION Cameras
| Name | AZM-FS10L | AZM-FS20L | AZM-FS30L2 | AZM-WQHS36L-LL |
| Datasheet | AZM-FS10L | AZM-FS20L | AZM-FS30L2 | AZM-WQHS36L-LL |
| Video Output Digital | LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits | LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits, 20bits (single LVDS mode) | LVDS Digital ITU-R BT.1120 - YcbCr4:2:2 16bits, 16bits | LVDS |
| Video Output Analog | SD CVBS (NTSC/PAL), 1.0Vp-p 75, Composite | SD CVBS (NTSC/PAL), 1.0Vp-p 75, Composite | HD-Analog / CVBS(※ Test Only) | |
| Camera Control Interface | Visca Protocol | Visca Protocol | Visca Protocol | Visca Protocol |
| Effectiv numbers of Pixels | Approx. 2,100,000 pixels | Approx. 2,100,000 pixels | Approx. 2,100,000 pixels | Approx. 5,450,000 pixels |
| Image sensor | 1/2.8 inch Sony Starvis CMOS Sensor (Progressive Scan) | 1/3-type CMOS (Progressive Scan) | 1/2.8 inch Sony Starvis CMOS Sensor (Progressive Scan) | 1/1.8" Sony IMX178LQJ-C CMOS Sensor (Progressive Scan) |
| Signal system (HD) | 1920x1080p@25,30,50,60 1920x1080p@29.97,59.94 (optional) 1920x1080i@50,60 1920x1080i@59.94 (optional) 1280x720p@25,30,50,60 1280x720p@29.97,59.94 (optional) |
1920x1080p@25,30,50,60 1920x1080i@50,60 1280x720p@25,30,50,60 | 1920x1080p@25,30,50,60,29.97,59.94 1920x1080i@50,60,59.94 1280x720p@25,30,50,60,29.97,59.94 | 1440p 30(25)fps, 1080p 30(25)fps, 720p 30(25)fps |
| Lens | Optical 10x, f = 4.7 mm to 47.0 mm (F 1.6 to F 3.0) | Optical 20x, f = 4.7 mm to 94 mm (F 1.6 to F 3.5) | Optical 30x, f = 4.7 mm to 141 mm (F 1.5 to F 4.0) | Optical x36, f = 6.0 mm to 216 mm (F1.5 to F4.8) |
| Horizontal viewing angle (wide to tele) | 57.7 degrees(WIDE), 6.4 degrees(TELE) | 57.4 degrees(WIDE), 3.2 degrees(TELE) | 60.5 degrees(WIDE) to 2.3 degrees(TELE) | 49.27 degrees(WIDE) to 1.85 degrees(TELE) |
| Digital Zoom | 12x | 12x | 12x | 32x |
TL6035 Sony FCB EV-7520 Camera Evaluation Kit
Partnumber: TL6035-EVK-FCB-EV7520
The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- Sony FCB EV-7520 Camera
- USB 3.0 Board (TL6035)
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
TL6035 Sony FCB FCB-EV9500L Camera Evaluation Kit
Partnumber: TL6035-EVK-FCB-FCB-EV9500L
The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- Sony FCB FCB-EV9500L Camera
- USB 3.0 Board (TL6035)
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
TL6035 Evaluation Kit
Partnumber: TL6035-EVK
The evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- USB 3.0 Board (TL6035)
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
TL6035 Production Kit
Partnumber: TL6035
Production kit with all items needed for production. Powerful, cheap , competitive
Parts:
- TL6035 Board
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm (TLCK-K30-200)
Camera connecting cable
Partnumber: TLCK-K30-200
KEL USL cable for the TL6032 interface board
Parts:
- 30 pin KEL USL type micro coaxial cable, connector on both sides, length 20cm
TL6035 Camera Evaluation Kit
Partnumber: TL6035-EVK-AZM-FSXXL
The camera evaluation kit contains all items to easily connect camera, interface & monitor. Ready to evaluate the camera in minutes rather than hours.
Parts:
- AZM-FS10L, AZM-FS20L, AZM-FS30L or AZM-WQHS36L-LL Block Camera
- USB 3.0 Board (TL6035)
- Power supply and control interface board (EK-PA1100-USB)
- 5 V AC to DC external power supply with interchangeable blade kit for USA, Europe, United Kingdom and Australian. (PS-TE10A05)
- USB to serial adapter (TL-EVK-USB-SA)
- Bracket and screws (TL-EVK-BRA)
- USB 3.0 Cable with a USB 3.0-A male and a USB 3.0 micro-B male connector
(TL-EVK-USB3.0-A-microB) - AIVION Visca Camera Control Software
